|
Post by stevecleethorpes on Aug 18, 2012 18:41:14 GMT
hi i was using my vespa last weekend and it ran fine, i have been away all week in the lorry and decided to go out on it today but it was a right swine to start and when it did start it will only run with the choke on,, if i turn the choke off it just cuts out unless i give it full throttle, if i set the idle screw so it ticks over fast and the take the choke off it seems like its starved of fuel i.e revving high as if its running out of fuel then just cuts out,, is this the seals? any help appreciated,, steve,, by the way its a t5 engine, regards .
|
|
bsr65
High Number
Posts: 114
|
Post by bsr65 on Aug 18, 2012 19:29:09 GMT
steve, remove the gear oil filler screw and top up with fresh oil,if it takes quite a bit chances are when you start your scoot smoke will betlch out the exhaust indicating a knackered main seal. ( so bloody common these days) hoprfully just a dirty carb problem though.
|
|
|
Post by stevecleethorpes on Aug 18, 2012 19:40:00 GMT
hi just topped up the gear oil and started it but no smoke as such from the exhaust?? ive removed the jets and even swapped the 112 main jet that i put in for the sito+ for the standard 110 jet but still the same,,steve
|
|
|
Post by bryno on Aug 18, 2012 20:14:12 GMT
Most likely crap in the carb mate rather than seals.
if youve done the jets, best get the whole carb off, clean out the filter, needle, bowl and the jet tubes as well.
If still no good, try running it with the filler cap off.
Again if no good, i'd be lifting the tank out and checking the fuel flow from the tank is good and steady, if not, pop the front off the tap and check for blockage there.
|
|
|
Post by stevecleethorpes on Aug 18, 2012 20:27:56 GMT
cheers bryno i will take the carb off tommorrow and clean it and see what happens,, i was looking forward to riding it after grafting all week ,, i will post my findings tommorrow ,,thanks again,, steve
|
|
|
Post by stevecleethorpes on Aug 19, 2012 9:29:13 GMT
right ,, morning everyone, just took carb off and stripped it down and cleaned it all etc etc, shouted and swore at it and gave it loads of verbal abuse,, put it all back on and fired it up,,, guess what it runs perfick without choke now ,, so either ive scared it sh*tless with all abuse i gave it or there must of been some crap in it hen i washed it in the bath ;D regards,,steve,, i shall report back in a bit when ive been for a ride down the sea front on it shortly,, toodle pip,
|
|
|
Post by stevecleethorpes on Aug 19, 2012 10:52:09 GMT
just to follow up,, ben for a ride around cleethorpes and it seems great behavng perfect,, i think its run in enough for me to take it for a thrash on the 180 and do a plug chop in a lay by if needs be i can take te 110 main jet ut and put a 112 in and try that,, thank the lord it wasnt me crank seals regards for now,,,steve
|
|